A PVC strip curtain is a row of flexible, overlapping plastic strips hung from a rail across a doorway, so that people and vehicles can pass through while the strips fall back to close the gap behind them. At loading bays they hang behind the main door or across internal openings, reducing draughts, dust and temperature loss for much less than the cost of a powered door.
Where does this fit at a dock in Perth and Kinross?
Goods-in areas in Perth and Kinross that leave the main door open during long unloading sessions can use a strip curtain to hold back draughts and dust. Food and packaging businesses in Perth and Kinross can choose strip grades suited to regular cleaning, helping to separate dispatch areas from production.
Wind-driven rain and leaves blowing into an open dock are a familiar nuisance, and a heavy-duty strip curtain is one simple response for sites in Perth and Kinross.
Our part of the job in Perth and Kinross is to survey, quote and manage; the fitting itself is done by specialist installation engineers working under our management. The survey and the written quote are free. Once the fixed price is accepted, we agree dates that work around your deliveries and shifts, including out-of-hours working where needed. Every installation is tested before handover, and you receive the documentation for each item fitted.
Are strip curtains safe where forklifts and pedestrians share an opening?
Strip curtains can be used where forklifts and pedestrians share an opening, but only if the strips stay clear enough for both to see through and the route is managed. Visibility is the main risk.
- Clear strips scratch and cloud with use, so a driver may not see a person on the other side.
- Ribbed strips and regular replacement keep visibility better for longer.
- A separate pedestrian door beside the vehicle opening is the safer arrangement.
- Floor markings and mirrors help where a separate door is not possible.
At very busy openings, a high-speed dock door with vision panels and safety sensors may be the better long-term answer, because it opens fully for each vehicle and closes again behind it. We can price both so you can compare the cost and the practical difference for your traffic.
Which strip width, thickness and grade should I choose?
Choose the strip size by the size of the opening and the traffic through it, and the grade by temperature and use. Wider, thicker strips seal better and resist forklifts, but are heavier to push through on foot.
- Pedestrian doorways: typically 200 mm wide by 2 mm thick strips with a modest overlap.
- Forklift openings: typically 300 mm wide by 3 mm thick, with a larger overlap.
- Large dock openings: typically 400 mm wide by 4 mm thick, which hang well in draughts.
- Low-temperature grade: stays flexible in chillers and freezers, where standard PVC would stiffen and crack.
- Ribbed strips: raised ribs take the wear from forklifts and keep the strips clearer for longer.
- Specialist grades: anti-static, tinted or opaque, or welding grade for screening.
Overlap matters as much as thickness. A full overlap gives a better seal in cold or dusty areas, while a partial overlap is easier to walk through.
Towns we cover in Perth and Kinross
Each of the following towns in Perth and Kinross has its own page on PVC strip curtains, covering how we work and what to send us.
Budget range for supply and fit. The written quote after a free survey is the fixed price. All guide prices.
Regulations and approvals in Scotland
Doors and dock equipment installed in Scotland may carry the UKCA or the CE mark, and we pass on the documentation for everything fitted in Perth and Kinross. Because building warrant and planning questions can affect the programme, we check what applies at survey and raise any approvals early rather than assuming none are needed.
Questions
Do you remove and dispose of the old equipment?
Yes, where it is part of the scope. When we replace doors, levellers, shelters or seals at a site in Perth and Kinross, removal and disposal of the old equipment can be included and is itemised in the quote, so it is clear what is covered. If anything should be kept, such as a frame or motor that is still serviceable, we agree that at survey.
Can you work outside our normal operating hours in Perth and Kinross?
Yes, by arrangement. Evening, night and weekend working can be planned so the installation causes as little disruption as possible to your loading schedule. Out-of-hours work can affect the price, so mention it at the survey and we will include it in the written quote. The agreed times are confirmed in the programme before the job starts.
Which grade should we use in a freezer?
Use a low-temperature or polar grade in a freezer. Standard PVC stiffens in the cold, so it cracks and stops falling back into place, leaving gaps. Low-temperature grades are formulated to stay flexible in chilled and frozen conditions, so they keep sealing after each vehicle passes.
Can strips be replaced individually?
Yes, individual strips can be unhooked or unclamped and replaced without taking down the whole curtain. Keeping a few spare strips on site lets your team swap damaged ones as soon as they appear, which keeps visibility and sealing consistent across the opening.
Other services in Perth and Kinross
Full guide to PVC strip curtains · All loading bay services in Perth and Kinross