A PVC strip curtain is a row of flexible, overlapping plastic strips hung from a rail across a doorway, so that people and vehicles can pass through while the strips fall back to close the gap behind them. At loading bays they hang behind the main door or across internal openings, reducing draughts, dust and temperature loss for much less than the cost of a powered door.
How does this suit sites in Forth Valley?
Chilled rooms off a dock in Forth Valley can lose temperature through internal doorways, and a low-temperature strip curtain is a quick, inexpensive fix. Goods-in areas in Forth Valley that leave the main door open during long unloading sessions can use a strip curtain to hold back draughts and dust.
Measuring an opening in Forth Valley for a strip curtain takes only a short visit, and we note traffic, temperature and fixings at the same time.
If you are planning PVC strip curtains for a site in Forth Valley, expect four stages. A free survey and fixed written quote come first. We then agree a programme with you, including any out-of-hours work. Specialist installation engineers carry out the installation under our management, with us as your single point of contact. Finally, the equipment is tested, your staff are shown how it works and everything is handed over with its documentation.
Do strip curtains count towards building energy rules?
A strip curtain does not replace the need for a compliant door: where a new or replacement external loading bay door is fitted, it is the door that has to meet the energy rules.
- England: Approved Document L (2021) Volume 2 sets a limiting U-value of 1.3 W/m²K for vehicle access and similar large doors in new and replacement work.
- Wales, Scotland and Northern Ireland: each nation has its own energy rules, through Approved Document L for Wales, Section 6 of the Scottish Building Standards Technical Handbook, and Technical Booklet F2 in Northern Ireland. We confirm what applies to your nation and project.
What a strip curtain does well is reduce the air moving through an opening while the door is open for loading. That helps a heated or chilled building, even though the curtain is not the door.
Workplace safety still applies around the curtain: strips should stay clear enough for drivers and pedestrians to see each other. HSE is the regulator in Great Britain and HSENI in Northern Ireland.
How are strip curtains fitted to a loading bay opening?
Strip curtains are fitted by fixing a rail across the head of the opening and hanging the strips from it, a job that usually takes an hour or two per opening and needs no power supply.
- Fixed rails: bolted to the lintel or wall above the opening, with strips hooked or clamped on.
- Sliding rails: let the whole curtain be pushed to one side for wide loads or warmer months.
- Swing-away rails: hinge back against the wall, useful where a door track runs close to the head of the opening.
At a dock the curtain usually sits just inside the main door, so we check it will not snag the door's bottom edge, the leveller lip or any tracks. From you we need the opening clear for the visit and agreement on whether strips should reach the floor or stop just above it. Strips that drag on the floor wear quickly and can catch on pallet trucks.
Towns we cover in Forth Valley
Each of the following towns in Forth Valley has its own page on PVC strip curtains, covering how we work and what to send us.
Budget range for supply and fit. The written quote after a free survey is the fixed price. All guide prices.
Regulations and approvals in Scotland
Doors and dock equipment installed in Scotland may carry the UKCA or the CE mark, and we pass on the documentation for everything fitted in Forth Valley. Because building warrant and planning questions can affect the programme, we check what applies at survey and raise any approvals early rather than assuming none are needed.
Questions
How do you price PVC strip curtains for a site in Forth Valley?
Guide budgets for supply and fit are £180 to £1,100 per opening, excluding VAT. The figure moves with size, insulation, the operator, electrics, access, any pit or groundworks and out-of-hours working. Where levellers are involved, the guide assumes an existing, sound pit. After the free survey you receive a fixed written quote, and that is the price for the agreed scope.
How long does installation take at a site in Forth Valley?
It depends on the equipment, the number of bays, the condition of the dock and whether any building or electrical work is needed. We agree a programme with you after the survey, setting out which bays are out of use and when. Larger jobs are usually phased so that part of the dock stays open, and out-of-hours working can be arranged.
Are strip curtains a good alternative to a high-speed door?
Strip curtains are a good low-cost option for moderate traffic, but at very busy openings a high-speed door often performs better because it clears fully for each vehicle and closes behind it. The right choice depends on traffic volume, visibility needs and budget.
Do strip curtains work at an external dock opening?
Yes, strip curtains are often hung just inside an external dock door to reduce draughts while the door is open for loading. They are not a substitute for the door itself, which still closes the opening for security and weather whenever the bay is not in use.
Other services in Forth Valley
Full guide to PVC strip curtains · All loading bay services in Forth Valley