- Location
- Enfield Lock, Greater London
- Main postcode districts
- EN3 and EN8
- Nearby (straight line)
- Waltham Abbey (1 mile), Cheshunt (2 miles) and Enfield (3 miles)
- Survey and quote
- Free, with a fixed written quote
A PVC strip curtain is a row of flexible, overlapping plastic strips hung from a rail across a doorway, so that people and vehicles can pass through while the strips fall back to close the gap behind them. At loading bays they hang behind the main door or across internal openings, reducing draughts, dust and temperature loss for much less than the cost of a powered door.
How does this suit sites in Enfield Lock?
Smaller trade units in Enfield Lock with a single goods door may find a strip curtain the most economical way to keep the working area warmer in winter. Measuring an opening in Enfield Lock for a strip curtain takes only a short visit, and we note traffic, temperature and fixings at the same time.
Goods-in areas in Enfield Lock that leave the main door open during long unloading sessions can use a strip curtain to hold back draughts and dust.
The survey is free, the quote is written and the price is fixed: that is how every installation in Enfield Lock begins. We then manage the work from start to finish. Fitting is carried out by specialist installers under our management, phased so the operation keeps moving, and nights or weekends can be booked by arrangement. On the final day we test the equipment with you and hand over the operating and maintenance information.
Are strip curtains safe where forklifts and pedestrians share an opening?
Strip curtains can be used where forklifts and pedestrians share an opening, but only if the strips stay clear enough for both to see through and the route is managed. Visibility is the main risk.
- Clear strips scratch and cloud with use, so a driver may not see a person on the other side.
- Ribbed strips and regular replacement keep visibility better for longer.
- A separate pedestrian door beside the vehicle opening is the safer arrangement.
- Floor markings and mirrors help where a separate door is not possible.
At very busy openings, a high-speed dock door with vision panels and safety sensors may be the better long-term answer, because it opens fully for each vehicle and closes again behind it. We can price both so you can compare the cost and the practical difference for your traffic.
How are strip curtains fitted to a loading bay opening?
Strip curtains are fitted by fixing a rail across the head of the opening and hanging the strips from it, a job that usually takes an hour or two per opening and needs no power supply.
- Fixed rails: bolted to the lintel or wall above the opening, with strips hooked or clamped on.
- Sliding rails: let the whole curtain be pushed to one side for wide loads or warmer months.
- Swing-away rails: hinge back against the wall, useful where a door track runs close to the head of the opening.
At a dock the curtain usually sits just inside the main door, so we check it will not snag the door's bottom edge, the leveller lip or any tracks. From you we need the opening clear for the visit and agreement on whether strips should reach the floor or stop just above it. Strips that drag on the floor wear quickly and can catch on pallet trucks.
The same published guide range applies across England; access, out-of-hours working and site conditions are confirmed at the free survey.
What we look at on site
- Age and condition of the equipment already in place
- Clear opening width and height for each door
- Asbestos register and any other site hazard information
- Condition of any existing leveller pit, kerb angles and pit drainage
- How often each door cycles during a typical shift
- Whether planning, building control or a building warrant may be needed
Options to discuss
Ribbed strips
Strips with raised ribs that take the abrasion from forklifts and pallets, helping them stay clearer for longer at busy openings.
Sliding or swing-away rail
A rail that lets the whole curtain be moved clear of the opening for wide loads, cleaning or seasonal removal without taking the strips down.
Regulations and approvals in England
Workplace safety in England is regulated by HSE. For a loading bay in Enfield Lock, that means doors meeting regulation 18 of the Workplace (Health, Safety and Welfare) Regulations 1992, equipment maintained under PUWER and suitable safeguards against vehicles driving away too early. We check what applies at survey and design the bay accordingly.
Questions about PVC strip curtains in Enfield Lock
What warranty comes with new loading bay equipment?
New equipment comes with the manufacturer's warranty, which varies by product. Our workmanship terms are set out in writing in the quote for your Enfield Lock site, so you can see what is covered before you commit. Check the warranty terms for any servicing conditions, and we can quote for planned maintenance once the installation is complete.
Can you work outside our normal operating hours in Enfield Lock?
Yes, by arrangement. Evening, night and weekend working can be planned so the installation causes as little disruption as possible to your loading schedule. Out-of-hours work can affect the price, so mention it at the survey and we will include it in the written quote. The agreed times are confirmed in the programme before the job starts.
Do you remove and dispose of the old equipment?
Yes, where it is part of the scope. When we replace doors, levellers, shelters or seals at a site in Enfield Lock, removal and disposal of the old equipment can be included and is itemised in the quote, so it is clear what is covered. If anything should be kept, such as a frame or motor that is still serviceable, we agree that at survey.
Which grade should we use in a freezer?
Use a low-temperature or polar grade in a freezer. Standard PVC stiffens in the cold, so it cracks and stops falling back into place, leaving gaps. Low-temperature grades are formulated to stay flexible in chilled and frozen conditions, so they keep sealing after each vehicle passes.
Do strip curtains work at an external dock opening?
Yes, strip curtains are often hung just inside an external dock door to reduce draughts while the door is open for loading. They are not a substitute for the door itself, which still closes the opening for security and weather whenever the bay is not in use.
PVC strip curtains near Enfield Lock
Close neighbours of Enfield Lock with their own pages here: Waltham Abbey (1 mile), Cheshunt (2 miles) and Enfield (3 miles). Choose one to see coverage details for that town.
Other loading bay services in Enfield Lock
Full guide to PVC strip curtains · Everything we do in Enfield Lock
If a loading bay in Enfield Lock needs attention, call us or send photos and details online.