- Location
- Ayr, Ayrshire
- Main postcode district
- KA7
- Nearby (straight line)
- Irvine (11 miles), Kilmarnock (12 miles) and Kilwinning (13 miles)
- Survey and quote
- Free, with a fixed written quote
A PVC strip curtain is a row of flexible, overlapping plastic strips hung from a rail across a doorway, so that people and vehicles can pass through while the strips fall back to close the gap behind them. At loading bays they hang behind the main door or across internal openings, reducing draughts, dust and temperature loss for much less than the cost of a powered door.
What should sites in Ayr consider?
Smaller trade units in Ayr with a single goods door may find a strip curtain the most economical way to keep the working area warmer in winter. Goods-in areas in Ayr that leave the main door open during long unloading sessions can use a strip curtain to hold back draughts and dust.
Wind-driven rain and leaves blowing into an open dock are a familiar nuisance, and a heavy-duty strip curtain is one simple response for sites in Ayr.
If you are planning PVC strip curtains for a site in Ayr, expect four stages. A free survey and fixed written quote come first. We then agree a programme with you, including any out-of-hours work. Specialist installation engineers carry out the installation under our management, with us as your single point of contact. Finally, the equipment is tested, your staff are shown how it works and everything is handed over with its documentation.
How are strip curtains fitted to a loading bay opening?
Strip curtains are fitted by fixing a rail across the head of the opening and hanging the strips from it, a job that usually takes an hour or two per opening and needs no power supply.
- Fixed rails: bolted to the lintel or wall above the opening, with strips hooked or clamped on.
- Sliding rails: let the whole curtain be pushed to one side for wide loads or warmer months.
- Swing-away rails: hinge back against the wall, useful where a door track runs close to the head of the opening.
At a dock the curtain usually sits just inside the main door, so we check it will not snag the door's bottom edge, the leveller lip or any tracks. From you we need the opening clear for the visit and agreement on whether strips should reach the floor or stop just above it. Strips that drag on the floor wear quickly and can catch on pallet trucks.
Are strip curtains safe where forklifts and pedestrians share an opening?
Strip curtains can be used where forklifts and pedestrians share an opening, but only if the strips stay clear enough for both to see through and the route is managed. Visibility is the main risk.
- Clear strips scratch and cloud with use, so a driver may not see a person on the other side.
- Ribbed strips and regular replacement keep visibility better for longer.
- A separate pedestrian door beside the vehicle opening is the safer arrangement.
- Floor markings and mirrors help where a separate door is not possible.
At very busy openings, a high-speed dock door with vision panels and safety sensors may be the better long-term answer, because it opens fully for each vehicle and closes again behind it. We can price both so you can compare the cost and the practical difference for your traffic.
The same published guide range applies across Scotland; access, out-of-hours working and site conditions are confirmed at the free survey.
What do we check at the survey?
- Condition of any existing leveller pit, kerb angles and pit drainage
- Power supply at each bay, including three-phase availability
- Wall and steel structure for door, shelter and bumper fixings
- Asbestos register and any other site hazard information
- Gaps around trailers where heated or chilled air escapes
- Drainage on recessed or sloping dock approaches
Options to discuss
Low-temperature strips
A grade formulated to stay flexible in chillers and freezers, where standard strips would stiffen, crack and stop falling back into place.
Ribbed strips
Strips with raised ribs that take the abrasion from forklifts and pallets, helping them stay clearer for longer at busy openings.
Regulations and approvals in Scotland
In Scotland, building work such as forming a new opening or a dock leveller pit may need a building warrant from the local authority before it starts. For sites in Ayr, external structures such as loading houses or canopies may also need planning permission from the council. We check what applies at survey and factor any approvals into the programme.
Questions about PVC strip curtains in Ayr
Do you remove and dispose of the old equipment?
Yes, where it is part of the scope. When we replace doors, levellers, shelters or seals at a site in Ayr, removal and disposal of the old equipment can be included and is itemised in the quote, so it is clear what is covered. If anything should be kept, such as a frame or motor that is still serviceable, we agree that at survey.
Do you cover Ayr for PVC strip curtains?
Yes. We take on PVC strip curtains for businesses in Ayr and across Ayrshire. We survey the site, provide a fixed written quote and manage the installation, with specialist installation engineers working under our management. Visits are arranged in advance at a time that suits your operation, and the same single contact stays with the job through to handover.
How do you price PVC strip curtains for a site in Ayr?
Guide budgets for supply and fit are £180 to £1,100 per opening, excluding VAT. The figure moves with size, insulation, the operator, electrics, access, any pit or groundworks and out-of-hours working. Where levellers are involved, the guide assumes an existing, sound pit. After the free survey you receive a fixed written quote, and that is the price for the agreed scope.
Which grade should we use in a freezer?
Use a low-temperature or polar grade in a freezer. Standard PVC stiffens in the cold, so it cracks and stops falling back into place, leaving gaps. Low-temperature grades are formulated to stay flexible in chilled and frozen conditions, so they keep sealing after each vehicle passes.
Can strips be replaced individually?
Yes, individual strips can be unhooked or unclamped and replaced without taking down the whole curtain. Keeping a few spare strips on site lets your team swap damaged ones as soon as they appear, which keeps visibility and sealing consistent across the opening.
PVC strip curtains near Ayr
Other towns within reach of Ayr on our coverage list include Irvine (11 miles), Kilmarnock (12 miles) and Kilwinning (13 miles), all covered on the same terms.
Other loading bay services in Ayr
Full guide to PVC strip curtains · Everything we do in Ayr
Phone us to discuss your loading bay in Ayr, or start with the online quote tool if you prefer to send details first.