Edge-of-dock levellers in Blantyre

Location

Blantyre, Lanarkshire

Main postcode districts

G71 and G72

Nearby (straight line)

Viewpark (3 miles), Cambuslang (3 miles) and Hamilton (3 miles)

Survey and quote

Free, with a fixed written quote

Is this right for your site in Blantyre?

Companies running their own vehicles in Blantyre, where every trailer has a known bed height, are well placed to use edge-of-dock levellers instead of pit units. On older buildings in Blantyre where drains or services run close to the dock, avoiding a pit can make an edge-of-dock leveller the sensible route.

Exposed external docks in Blantyre call for a galvanised or well-painted edge-of-dock leveller that stands up to the weather all year round.

If you are planning edge-of-dock levellers for a site in Blantyre, expect four stages. A free survey and fixed written quote come first. We then agree a programme with you, including any out-of-hours work. Specialist installation engineers carry out the installation under our management, with us as your single point of contact. Finally, the equipment is tested, your staff are shown how it works and everything is handed over with its documentation.

How much height difference can an edge-of-dock leveller handle?

An edge-of-dock leveller can only handle a small height difference, typically in the region of 75 to 150 mm above and below dock level depending on the model. That is enough where trailers are consistent, but not where bed heights vary widely.

Typical UK docks are around 1,200 mm above yard level, while trailer bed heights can range from roughly 900 to 1,600 mm across rigid, curtain-sider, refrigerated, double-deck and container chassis. If your trailers sit outside the leveller's range, the plate becomes too steep to use safely.

• Good fit: dedicated fleets or regular suppliers with similar trailers.
• Poor fit: sites receiving everything from low rigids to high double-deck trailers.

Where trailer heights vary, a pit leveller such as a swing-lip dock leveller gives a much longer, gentler ramp. We record your trailer heights at survey to confirm which suits.

Should I choose a mechanical or hydraulic edge-of-dock leveller?

Choose a mechanical edge-of-dock leveller for occasional use and simple sites, and a hydraulic one where the bay is busy or operators need push-button control. Both bridge a similar small height range.

• Mechanical: the operator pulls a lever or handle and the lip lifts and drops onto the bed with spring assistance. No power is needed and there is little to go wrong, but it takes some physical effort.
• Hydraulic: a push button raises the plate and extends the lip, then lowers it onto the trailer. It is easier and quicker for frequent use and can be interlocked with the dock door and traffic lights.

Other choices include plate width, which should suit the wheel track of your pallet trucks and forklifts, and capacity, which must cover the truck and its heaviest load. On exposed external docks, a galvanised or well-painted finish helps the unit cope with rain, frost and road salt.

What does the free survey cover?

• Forklift and pallet truck loads crossing the leveller platform
• Wheel guide positions and yard markings for reversing vehicles
• Dock height and the mix of trailers you load
• Clear opening width and height for each door
• Power supply at each bay, including three-phase availability
• Temperature requirements for chilled, frozen or ambient goods

Options to discuss

Planning, building control and safety law in Scotland

In Scotland, building work such as forming a new opening or a dock leveller pit may need a building warrant from the local authority before it starts. For sites in Blantyre, external structures such as loading houses or canopies may also need planning permission from the council. We check what applies at survey and factor any approvals into the programme.

Questions about edge-of-dock levellers in Blantyre

Edge-of-dock levellers near Blantyre

Looking beyond Blantyre? Our pages for Viewpark (3 miles), Cambuslang (3 miles) and Hamilton (3 miles) describe the same loading bay services and how to get in touch.

• Viewpark
• Cambuslang
• Hamilton
• Bellshill
• East Kilbride
• All of Lanarkshire

Other loading bay services in Blantyre

• Scissor lift tablesDock lifts that raise goods to trailer height at ground-level doors.
• Loading bay door repairsRepairs to sectional doors, shutters and high-speed doors at the dock.
• Dock lights and wheel guidesSwing-arm dock lights and steel wheel guides for accurate reversing.
• Loading bay servicingPlanned maintenance for doors, levellers, shelters and restraints.
• Dock leveller repairsHydraulic, lip, hinge and control repairs to all common leveller types.
• Loading housesInsulated external dock pods with leveller and shelter built in.

Full guide to edge-of-dock levellers · Everything we do in Blantyre

Send a few photos of the dock and a short description of the problem, and we will come back to you about your Blantyre site.